features built-in strain relief glass passivated junction low inductance mechanical data case: jedec do-41 molded plastic over passivated junction weight: 0.012 ounce, 0.34 gram terminals : solder plated, solderable per mil-std-750, method 2026 2ez5.6d5 thru 2ez75d5 2 w glass passivated junction silicon zener diode 5.6-75 volts excellent clamping capability polarity : color band denotes positive end (cathode) maximum ratings @ 25 o c unless otherwise specified 2 watts derate above 75 c 24 mw/ c peak forward surge current 8.3ms single operating and storage temperature range t j ,t stg -55 o c to +150 o c o peak pulse power dissipation (note a) o half sine-wave superimposed on rated load (jedec method) (note b) i fsm 15 amps p d notes: a. mounted on 5.0mm 2 (.013mm thick) land areas. b. measured on 8.3ms, single half sine-wave or equivalent square wave, duty cycle = 4 pulses per minute maximum.
omp onents 20736 marilla street chatsworth
revision: 7 2006/10/11 mcc tm micro commercial components do-41 dimensions inches mm dim min max min max note a .166 .205 4.10 5.20 b .080 .107 2.00 2.70 c .028 .034 .70 .90 d 1.000 --- 25.40 --- a b c d d cathode mark www. mccsemi .com 1 of 5
2ez5.6d5 t h r u 2 e electrical characteristics ( t a =25 unless otherwise noted ) v f =1.2 v max , i f =500 ma for all t y p es 5 d 5 7 z type no. nominal zener test maximum zener surge current (note 1.) voltage vz @ i zt current current @ t a = 25 volts i zt z zt @ i zt z zk @ i zk i zk i r v r i zm izsm - a (note 2.) ma ohms ohms ma ua max volts m a (note 4.) 2ez5.6d5 5.6 89.5 2.5 500 1 5 2 324 3.3 2ez6.2d5 6.2 80.5 1.5 700 1 5 3 292 3.1 2ez6.8d5 6.8 73.5 2 700 1 5 4 266 2.9 2ez7.5d5 7.5 66.5 2 700 0.5 5 5 242 2.66 2ez8.2d5 8.2 61 2.3 700 0.5 5 6 220 2.44 2ez9.1d5 9.1 55 2.5 700 0.5 3 7 200 2.2 2ez10d5 10 50 3.5 700 0.25 3 7.6 182 2 2ez11d5 5.6 45.5 4 700 0.25 1 8.4 166 1.82 2ez12d5 12 41.5 4.5 700 0.25 0.5 9.1 152 1.66 2ez13d5 13 38.5 5 700 0.25 0.5 9.9 138 1.54 2ez14d5 14 35.7 5.5 700 0.25 0.5 10.6 130 1.43 2ez15d5 15 33.4 7 700 0.25 0.5 11.4 122 1.33 2ez16d5 16 31.2 8 700 0.25 0.5 12.2 114 1.25 2ez17d5 17 29.4 9 750 0.25 0.5 13 107 1.18 2ez11d5 11 45.5 4 700 0.25 1 8.4 166 1.82 2ez12d5 12 41.5 4.5 700 0.25 1 9.1 152 1.66 2ez13d5 13 38.5 5 700 0.25 0.5 9.9 138 1.54 2ez14d5 14 35.7 5.5 700 0.25 0.5 10.6 130 1.43 2ez15d5 15 33.4 7 700 0.25 0.5 11.4 122 1.33 2ez16d5 16 31.2 8 700 0.25 0.5 12.2 114 1.25 2ez17d5 17 29.4 9 750 0.25 0.5 13 107 1.18 2ez18d5 18 27.8 10 750 0.25 0.5 13.7 100 1.11 2ez19d5 19 26.3 11 750 0.25 0.5 14.4 95 1.05 2ez20d5 20 25 11 750 0.25 0.5 15.2 90 1 2ez22d5 22 22.8 12 750 0.25 0.5 16.7 82 0.91 2ez24d5 24 20.8 13 750 0.25 0.5 18.2 76 0.83 2ez27d5 27 18.5 18 750 0.25 0.5 20.6 68 0.74 2ez30d5 30 16.6 20 1000 0.25 0.5 22.5 60 0.67 2ez33d5 33 15.1 23 1000 0.25 0.5 25.1 55 0.61 2ez36d5 36 13.9 25 1000 0.25 0.5 27.4 50 0.56 2ez39d5 39 12.8 30 1000 0.25 0.5 29.7 47 0.51 2ez43d5 43 11.6 35 1500 0.25 0.5 32.7 43 0.45 2ez47d5 47 10.6 40 1500 0.25 0.5 35.8 39 0.42 2ez51d5 51 9.8 48 1500 0.25 0.5 38.8 36 0.39 2ez56d5 56 9 55 2000 0.25 0.5 42.6 32 0.36 2EZ62D5 62 8.1 60 2000 0.25 0.5 47.1 29 0.32 2ez68d5 68 7.4 75 2000 0.25 0.5 51.7 27 0.29 2ez75d5 75 6.7 90 2000 0.25 0.5 56 24 0.27 leakage current maximum zener impedance (note 3) o c o c 3.zener impedance (zz) derivation - the zener impedance is derived from the 60 cycle ac voltage, which results when an ac current having an rms falue equal to 10% of the dc zener current (i zt or i zk )is superimposed on i zt or i zk . . 4. surge current (izsm) non-repetitive - the rating listed in the electrical characteristics table is maximum peak, non-repetitive, reverse surge current of 1/2 square wave or equivalent sine wave pulse of 1/120 second duration superimposed on the test current, i zt , per jedec standards, however, actual device capability is as described in figure 3. mcc revision: 7 2006/10/11 tm micro commercial components 1. tolerances - suffix indicates 5% tolerance any other tolerance will be considered as a special device. 2. zener voltage (vz) measurement - guarantees the zener voltage when measured at 40 ms from the diode body, and an ambient temperature of 25 . notes : www. mccsemi .com 2 of 5
rating and characteristics curves 2ez 5.6 d5 thru 2ez75d5 30 20 10 7 5 3 2 1 0.7 0.5 0.3 0.0001 0.0002 0.0005 0.001 0.002 0.005 0.01 0.02 0.05 0.1 0.2 0.5 1 2 5 10 d=0.5 0.2 0.1 0.05 0.02 0.01 d=0 note below 0.1 second , thermal response curve is applicable to any lead length (l) single pulse tjl = jl(t)ppk repetitive pulses tjl = jl(t,d)ppk fig. 2-typical thermal response 500 250 150 100 50 30 20 10 .1 .2 .3 5 1 235 10 20 50 100 rectangular nonrepetitive waveform tj = 25 prior to initial pulse p.w . p u l se w i d t h ( ms ) 0.1 0.05 0.03 0.02 0.01 0.005 0.003 0.002 0.001 0.0005 0.0003 0.0002 0.0001 1 2 5 10 20 50 100 200 500 1k nom i n a l vz ( volts ) fig. 3-maximum surge power fig. 4-typical reverse leakage 8 6 4 2 0 -2 -4 3 4 6 8 10 12 range vz , zener voltage @ izt ( volts ) 200 100 50 40 30 20 10 0 20 40 60 80 100 120 140 160 180 200 range vz , zener v o l t age @ izt ( volts ) fig. 5-units 3.9 to 12 volts fig. 6-units 10 to 200 volts jl (t,d) transient thermal resistance junction-to-lead(/w) ppk, peak surge power(watts) ir, reverse leadage(uadc) @vr as specified in elec. char. table vz, temperature coefficient(mv/) @ izt vz, temperature c oefficient(mv ) @ izt mcc revision: 7 2006/10/11 tm micro commercial components www. mccsemi .com 3 of 5
rating and characteristics curves 2ez 5.6 d5 thru 2ez75d5 100 50 30 20 10 5 3 2 1 0.5 0.3 0.2 0.1 0 1 2 3 4 5 6 7 8 9 10 vz, zener voltage ( volts ) 100 50 30 20 10 5 3 2 1 0.5 0.3 0.2 0.1 0 10 20 30 40 50 60 70 80 90 100 vz, zen e r voltage ( volts ) fig. 7-vz = 3.9 thru 10 volts fig. 8-vz = 12 thru 82 volts 100 50 30 20 10 5 3 2 1 0.5 0.3 0.2 0.1 100 120 140 160 180 200 vz , zener voltage ( volts ) 80 70 60 50 40 30 20 10 0 0 1/8 1/4 3/8 1/2 5/8 3/4 7/8 1 primary path of conduction is through the cathode lead l, lead len g t h t oheatsink ( inch ) fig. 9-vz = 100 thru 200 volts fig. 10-typical thermal resistance iz, zener current (ma) iz, zener current (ma) iz, zener current (ma) jl, junction-lead thermal resistance ( /w) mcc revision: 7 2006/10/11 tm micro commercial components www. mccsemi .com 4 of 5
mcc revision: 7 2006/10/11 tm micro commercial components www. mccsemi .com 5 of 5 products are represented on our website, harmless against all damages. ***applications disclaimer*** ***important notice*** aerospace or military applications. products offer by micro commercial components corp . are not intended for use in medical, micro commercial components corp . reserve s the right to make changes without further notice to any product herein to make corrections, modifications , enhancements , improvements , or other changes . micro commercial components corp . does not assume any liability arising out of the application or use of any product described herein; neither does it convey any license under its patent rights ,nor the rights of others . the user of products in such applications shall assume all risks of such use and will agree to hold micro commercial components corp . and all the companies whose
|
